發動機推拉鋼索檢查(編輯修改稿)
2025-09-18 14:19 本頁面
【文章內容簡介】 THE THRUST AND/OR THE REVERSE THRUST LEVERS TO EXPOSE THOSE PORTIONS OF THE CABLES.: 第一項是檢查鋼索。 第二項是檢查鋼索接頭,第三項是檢查導向滑輪。 THERE ARE THREE PARTS FOR THE INSPECTION: THE FIRST TASK IS AN INSPECTION OF THE CONTROL CABLE WIRE ROPE。 THE SECOND TASK IS AN INSPECTION OF THE CONTROL CABLE FITTINGS. THE THIRD TASK IN AN INSPECTION OF THE PULLEYS.注: 三項工作可同時進行:NOTE: THESE THREE TASKS MAY BE PERFORMED CONCURRENTLY AT ONE LOCATION OF THE CABLE SYSTEM ON THE AIRPLANE.1. 鋼索檢查 (參考 AMM202002/601,附錄 7 ).INSPECTION OF THE CONTROL CABLE WIRE ROPE. (REFER AMM202002/601,APPENDIX 7).EO編號No B576005修訂號 Rev No R1GAMECO 工程指令GAMECO ENGINEERING ORDERPage 5 of 10發動機推力控制鋼索的檢查標題SUBJECT ENGING THRUST CONTROL CABLE INSPECTION施 工 說 明ACCOMPLISHMENT INSTRUCTION工作者M(jìn)ECH檢驗員INSP表 (FORM) 740001C a. 做詳細的目視檢查,來確認鋼索除了與滑輪和扇形輪,鋼索密封裝置以及膠套接觸外,沒有與其它的附件相磨. 如果有相磨的跡象就進行修理 (參考圖 1).PERFORM A DETAILED VISUAL INSPECTION TO ENSURE THAT THE CABLE DOES NOT CONTACT PARTS OTHER THAN PULLEYS, QUADRANTS, CABLE SEALS, OR GROMMETS INSTALLED TO CONTROL THE CABLE ROUTING. LOOK FOR EVIDENCE TO CONTACT WITH OTHER PARTS. CORRECT THE CONDITION IF EVIDENCE OF CONTACT IS FOUND (REFER FIGURE 1).注: 這個詳細的目視檢查被定義為: 一個對指定結構區域,系統,安裝或組裝的細致的徹底的目視檢查,來找出損壞,失效或缺陷情況. 工作中要執行鋼索的接近和表面清潔程序,檢驗員要借助燈光和鏡子來進行檢查.NOTE: FOR THE PURPOSES OF THIS PROCEDURE, A DETAILED VISUAL INSPECTION IS DEFINED AS: “ AN INTENSIVE VISUAL EXAMINATION OF A SPECIFIC SRRUCTURAL AREA, SYSTEM, INSTALLATION, OR ASSEMBLY TO DETECT DAMAGE, FAILURE, OR IRREGULARITY. AVAILABLE LIGHT IS NORMALLY SUPPLEMENTED WITH A DIRECT SOURCE OF GOOD LIGHTING AS INTENSITY DEEMED APPROPRIATEE BY THE INSPECTOR. INSPECTION AIDS SUCH AS MIRROR, MAGIFYIING LENSES,ETC., MAY BE USED. SURFACE CLLEANING AND ELABORATE ACCESS PROCEDURES MAY BE REQUIRED.”,來找出錯誤的走向,鋼索的打結或其它的損壞. 如果有以下的情況就更換鋼索 (參考 AMM761103/201,附錄 1):PERFORM A DETAILED VISUAL INSPECTION OF THE CABLE RUNS TO DETECT INCORRECT ROUTING, KINKS IN THE WIRE ROPE, OR OTHER DAMAGE. REPLACE THE CABLE ASSEMBLY (REFER AMM761103/201, APPENDIX 1) IF:(1) 受磨損的一股鋼索里, 一根鋼絲的截面積減少 40%(參考 AMM202002/圖 601,附錄 7).ONE CABLE STRAND HAD WORN W
范文總結相關推薦
鄂ICP備17016276號-1