【正文】 0米左右，屬高海拔地區，燒成系統工藝設計和設備選型將是整個工藝技術方案的關鍵，本可研重點考慮：高海拔對窯系統產量和熱耗均有顯著的影響。 通過方案對比認為立磨系統方案較優于球磨方案，節電效果顯著，對原料的水分、粒度適應性強，結構緊湊，集選粉和烘干為一體，工藝流程簡單、操作可靠，產品細度調整方便，設備可露天化布置，是理想的節能粉磨設備，本可研推薦選用立磨方案，在項目實施時需對原料進行易磨性試驗。（2）噸產品裝機功率小，電耗低。 （1）生產流程簡單、投資小 單段破碎系統與兩段破碎系統比較，車間設備減少了60%（按臺計），總設備重量約減少了40%。 單段破碎系統：選用一臺新型 單段錘式破碎機，當進料粒度≤850mm，出料粒度小于25mm（90%）時，系統產量320t/h, 一班生產。石灰石破碎車間年要求處理能力776860噸，日要求處理能力2504噸。來自水泥庫的水泥由提升機卸入推動篩，篩去雜物后進入衡壓倉，再進入八嘴回轉式包裝及包裝成袋裝水泥，由電子秤計量，包裝后的水泥由帶式輸送機送至2460m成品庫內堆存。散裝與包裝比例設計為70%：30%。均化用氣由庫底羅茨風機供給。1．6．11 水泥粉磨及輸送13m中心傳動雙滑履磨，配輥壓機及V型選粉機，臺時產量110 t／h，出磨水泥送至水泥庫中儲存。進廠濕混合材露天堆放，用裝載機送入卸料斗，由提升機送入烘干機，烘干后的混合材由提升送入混合材庫儲存。1．6．10 混合材烘干 用干排粉煤灰作混合材，可以不設烘干。冷卻后的熟料經鏈斗輸送機直接送入熟料中轉庫儲存。當增濕塔工作不正常時，收下的窯灰水分過大，增濕塔下的螺旋輸送機反轉將濕窯灰排出，再由人工清出。生料磨停運時，窯尾預熱器排出的廢氣可全部進入除塵器凈化后排放。熟料冷卻機排出的氣體；一部分作為二次風及三次風入窯和分解爐；部分作為煤磨的烘干熱源，其余廢氣經袋收塵器凈化后排入大氣。熟料冷卻機采用控制流篦式冷卻機，帶有熟料破碎機。窯的設計指標為日產熟料2000噸，燒成熱耗 3469 kJ/kg熟料（高原折減后實際為31113178 kJ/kg熟料）。為保證安全生產，本系統設有防爆閥及CO2 滅火裝置。煤粉倉下設有環狀天平計重機，既可計量，又能調節喂煤量。煤磨烘干氣體來自窯頭篦冷機煙氣，并設有備用熱風爐。出磨煤粉隨氣流經動態選粉機收集后，送入煤粉倉。m篩余8%－12％，終水分≤%的條件下，系統產量16t/h。攪拌倉帶有荷重傳感器及充氣裝置，倉內的生料經氣體攪拌后，自倉下流量控制閥卸出，由固體流量計量，經斗提機、空氣斜槽、送入窯尾旋風預熱器二級筒的上升管道系統。生料均化庫由羅茨風機供氣，經設在庫底的六個卸料口按順序卸至攪拌倉。 來自原料磨的成品生料及窯尾廢氣處理系統收集的粉塵經斗提機、空氣斜槽入庫。生料磨采用出窯尾預熱器廢氣為烘干熱源。m篩余12%，終水分≤%的條件下，系統產量為180t/h。1．6．5 生料粉磨配合好的原料送入立式磨中，出磨合格生料經高效旋風收塵器及窯尾袋收塵器收集，由鏈運機、斗式提升機送至生料均化庫儲存。庫底用電子皮帶秤按要求的配比準確計量配料后，經皮帶輸送機、提升機送至原料磨。1．6．3 粘土及均化輸送粘土由皮帶輸送機送至粘土簡易預均化堆棚，均化后的粘土送至原料配料庫內儲存。（3）無煙煤：燒成用無煙煤可供給的礦點較多，成分及熱值難以保證，為縮小偏差，保證燒成用煤質量的穩定性及均勻性，節約投資，故設計中考慮對無煙煤采取簡易預均化措施。采用二座Φ1536米儲存庫多點下料簡易搭配方式進行均化。 主要經濟技術指標 詳見表11。富源縣老廠宏發水泥廠根據我國和我省建材工業發展戰略的要求，為切實貫徹中央關于經濟結構調整的精神，堅持“控制總量、調整結構、淘汰落后”的建材工業發展方針和提高旋窯水泥比重的產業政策，實現水泥工業增長方式的轉變和可持續發展，為了適應曲靖市及富源縣的城鎮基礎設施建設、旅游區開發建設的需要，為謀求長遠發展，使產品上檔次、上規模，富源縣老廠宏發公司從企業自身條件和資金籌措能力等具體情況出發，因地制宜的綜合考慮，決定抓住西部大開發戰略的機遇，充分利用本地充足的資源，建設2000t/d新型干法熟料水泥生產線。具體為：2007年453萬t，2008年411萬t，2009年不少于139萬t，2010年不少于61萬t。云南省政府辦公廳下發的《關于做好淘汰落后水泥生產能力工作的通知》，明確提出了云南省“十一五”期間，淘汰落后水泥生產能力的具體目標、重點、進度和政策措施。老線可以利用的條件主要是：建設場地、礦山開采及運輸、工廠現有的生活設施及輔助生產設施（如機修、化驗室、辦公樓等）。是富源縣管理水平較高，產品質量較好的私營企業，為富源縣的經濟發展作出了重要貢獻。輔助生產設施：如機修、化驗室、辦公樓等，以及生活福利設施，利用企業原有設施。年發電量為2232104kWh，年供電量為2053104kWh。產品方案：熟料2000噸/日，窯年運轉率85%，水泥78萬噸/年。廠區附近有完善的供電、供水設施。In future, astronauts will be required to descend from a spaceship while it is still in space and富源縣老廠宏發水泥廠2000t/d熟料水泥生產線工程節能專篇1 項目概況 項目名稱富源縣老廠宏發水泥廠2000t/d熟料水泥生產線工程（帶4000kW純低溫余熱發電）項目。 As she walked away, I followed her out of the fair. she asked impatiently. 39。 As soon as I went outside, I forgot all about Madam Bellinsky because my wife hurried towards me. 39。At a village fair, I decided to visit a fortuneteller called Madam Bellinsky. I went into her tent and she told me to sit down. After I had given her some money, she looked into a crystal ball and said: 39。Our dog, Rex, used to sit outside our front gate and bark. Every time he wanted to e into the garden he would bark until someone opened the gate. As the neighbours plained of the noise, my husband spent weeks training him to press his paw on the latch to let himself in. Rex soon became an expert at opening the gate. However, when I was going out shopping last week, I noticed him in the garden near the gate. This time he was barking so that someone would let him out ! Since then, he has developed another bad habit. As soon as he opens the gate from the outside, he es into the garden and waits until the gate shuts. Then he sits and barks until someone lets him out. After this he immediately lets himself in and begins barking again. Yesterday my husband removed the gate and Rex got so annoyed we have not seen him since. if he picks a leaf, he will die. Many villagers believe that the tree has already claimed a number of victims. The vicar has been asked to have the tree cut down, but so far he has refused. He has pointed out that the tree is a useful source of ine as tourists have been ing from all parts of the country to see it. In spite of all that has been said, the touristshave been picking leaves and cutting their names on the treetrunk. So far, not one of them has been struck down by sudden death!cursed tree39。Lesson58 A blessing in disguise? 是因禍得福嗎？The Revealer39。Lesson55 Not a gold mine 并非金礦Lesson54 Sticky fingers 粘糊的手指Lesson53 Hot snake 觸電的蛇t need bookcases at all. You can sit here in your spare time and read the carpet!39。 she said. She gazed at it for some time then added, 39。We have just moved into a new house and I have been working hard all morning. I have been trying to get my new room in order. This has not been easy because I own over a thousand books. To make matters worse, the room is rather small, so I have temporarily put my books on the floor. At the moment, they cover every inch of floor space and I actually have to walk on them to get in or out of the room. A short while ago, my sister helped me to carry one of my old bookcases up the stairs. She went into my room and got a big surprise when she saw all those books on the floor. 39。My friend, Herbert, has always been fat, but things got so bad recently that he decided to go on a diet. He began his diet a week ago. First of all, he wrote out a long list of all the foods which were forbidden. The list included most of the things Herbert loves: butter, potatoes, rice, beer, milk, chocolate, and sweets. Yesterday I paid him a visit. I rang the bell and was not surprised to see that Herbert was still as fat as ever. He led me into his room and hurriedly hid a large parcel under his desk. It was obvious that he was very embarrassed. When I asked him what he was doing, he smiled guiltily and then put the parcel on the desk. He explained that his diet was so strict that he had to reward himself occasionally. Then he showed me the contents of the parcel. It contained five large bars of chocolate and three bags of sweets! I answered. said the conductor. 39。 39。I39。t matter,39。 39。 said the conductor suddenly.39。 I asked. 39。 39。 the conductor said. 39。 You39。 answered the conductor. I39。t know where it is.39。 I said to the conductor as I got o