【正文】 arameter： Capacity： 15m3 Size： Φ27202800mm Material ： PE Configuration: columned tank Liquid level control switch: with switch signal export. 經砂濾和活性炭過濾器過濾的水，收集在中間水箱中，供后續系統處理。 filtrate flow velocity： filtrate flux of unit： quantity： 1sets multiway valve： 1set installation form： Top entry 活性炭濾器系統參數 過濾系統型號： Ф900H1800mm 材質： FRP 單元過濾面積： 178。 Active carbon filter module： Ф900H1800mm material： FRP unit filtration area： 178。 活性炭過濾器同砂過濾器，均采用多路閥控制，活性炭過濾器反洗采用砂過濾器產水反洗，采用時間控制，即當任何一臺活性炭濾器運行時間達到設定值時，則停止運行。水通過炭床，水中有機污染物、細菌、膠體等顆粒被活性炭有效地吸附。 總體過濾面積： 178。 Totally filtration area： 178。反洗的過濾器完成反洗過程后，自動進入運行狀態。 ——過濾器采用專門用于反滲透預處理系統中的砂過濾器，填料為精選石英砂，以保證良好的過濾 效果，且不會在反洗過程中出現亂層現象。 ——采用較低的運行流速，以適應地表水的特點。 管道混合器： 流 量： 15t/h 流速： ~1m/h 材質： UPVC 接口： DN65， 法蘭連接 （ 4） Sand filter 砂過濾器 Sand filter is an important pretreatment set for RO system. And it is specially designed here according to the raw water quality. It can remove granule, suspended solid, colloid, anic pounds and congregated objects and protect the RO membrane from damage or pollution. Characteristic of **** sand filter are as follows: Effectively remove of suspended solid, colloid, anic pounds from the raw water. ——Particular and symmetrical water distribution ensured the optimization of filter efficiency to make sure the outlet water SDI meet RO inlet water requirement. 10t/h 脫鹽水系統 20 ——Low flow velocity will be introduced according to the character of surface water. ——Long period of operation. ——The sand filter is specially designed for RO pretreatment system. Choice quartz sand makes a good filtration and against from layerdisorder when backwashing. Multiway valve control shall control the sand filter. And the backwash period will be controlled by time. When running time of the sand filter has reached the set time, it will be stop. Multiway valve will open the backwash waterway and take backwash procedure automatically. The sand filter will enter work state automatically after the backwash. 砂過濾器是反滲透系統重要的預處理裝置，本系統采用專門針對用戶原水水質特點而設計的砂過濾器，它的作用是濾除原水中的細小顆粒、懸浮物、膠體、有機物等雜質，以及經加藥后形成的大顆粒，從而起到保護反滲透的作用 . 特點： ——能夠有效地去除原水中的膠體、懸浮物及有機物等。 殺菌劑加藥系統的作用是防止微生物生長。 由于系統進水受到有機物污染，水中的其他雜質如懸浮物、膠體等往往帶有一定量的同性電荷，它們相互排斥，難以自動聚集成大顆粒。 (3) Dosing system 加藥系統 The system is equipmented with coagulant dosing and bactericide dosing system here. 10t/h 脫鹽水系統 16 Through coagulant dosing system, coagulants will add into the raw water to congregate the suspended solid, anic pound, colloid, etc to prove filtration efficiency. The impurity such as suspended solid, colloid generally be of homo electric charge, which made them exclude each other and hard to congregate. coagulant is kind of long chain macromolecule. It can neutralize the doubleelectric layer of colloid and counteract heterogeneous group as well as adsorb the suspended solid, anic pound, colloid and congregate them to big objects and then removed by sand filter. Bactericide dosing system is used to prevent the growth of animalcule. 加藥系統分為 混 凝劑加藥系統與殺菌劑加藥系統。 本系統采用 2 臺立式離心泵。根據招標書要求，原水箱容積為 15m3，材質為 PE， 為了便于控制，原水箱配液位開關。 預處理系統的處理對象主要是進水中的機械雜質、膠體、鐵、微生物、藻類、有機物等。 為了保證反滲透系統正常運行，需定期對預處理系統出水水質進行檢測，檢測水樣從碳濾器產水總管采集，采用人工檢測，檢測頻率初定為一天兩次，主要檢測指標為 SDI值。 wayer balancechart 系統水量平衡圖（見下頁） RW: raw water RWT: raw water tank SF: sand filter ACF: active carbon filter IT: intermedia tank 1st:1st RO 10t/h 脫鹽水系統 10 2nd:2nd RO DIT: DI water tank CR: concentration return BD: backwash drain CD: concentration drain Process flow chart 工藝流程圖 Abbreviation: RW: raw water RWT: raw water tank RP: raw water pump BC: bactericide PM: pipe mixer SF: sand filter ACF: active carbon filter 1t/h RW 原水 SF 砂 過濾器 1st PassRO 一級 RO RWT 原水池 CD 濃排水 Tank 脫鹽水 箱 BD 反洗水 Tank 中間水池 ACF 活性炭過濾器 11t/h 10t/h CR 濃水回流 2nd Pass RO 二 級 RO BD 反洗水 10t/h 脫鹽水系統 11 BS: backwash system IT: intermedia tank 1st ROP:1st Pass RO supply pump SI: scaling inhibitor 1st ROSF: 1st Pass RO security filter CR: concentration return 1stROHP: 1st Pass RO high pressure pump CD: concentration drain CC: chemical cleaning 1st RO: 1st Pass RO set 2nd ROHP: 2nd Pass RO high pressure pump 2nd RO: 2nd Pass RO set DIT: DI water tank DISP: DI water booster pump PU: point of use Specification: Sand Filter system include: Sand Filter, backwash system, control instrument, etc. Active carbon Filter system include: Active carbon Filter, backwash system, control instrument, etc. RO system include: RO protective filter， highpressure pump, RO units, RO cleaning system, control instrument, etc. 過濾器系統包括：砂過濾器、砂過濾器反洗系統、控制儀表等； 活性炭過濾器系統包括：活性炭過濾器、活性炭過濾器反沖洗系統、控制儀表等； 反滲透系統包括：保安過 濾器、高壓泵、反滲透膜組、反滲透清洗系統和控二級反滲透產水箱 二級反滲透產水箱 10t/h 脫鹽水系統 12 制儀表等。反滲透可降低水的含鹽量和電導率，使出水水質符合要求。 由于，反滲透是比較精密的水處理系統，原水只有經過合理、可靠的預處理，才能不對反滲透系統造 成污染或?qū)⑽廴境潭冉档阶畹?，從而很好的保護了核心除鹽系統，延長反滲透膜的使用壽命，大大降低運行成本和維護成本，因此，為本系統配置先進、可靠的預處理工藝：砂過濾器＋活性炭過濾器。 proposal design idea 方案設計思路 The treatment process, sand filter amp。依據業主提供水質報告及業主對本系統的要求，本系統采用我公司設計制造的砂過濾器 +活性炭過濾器作為預處理設備，設備運行穩定，抗沖擊負荷 能力強，除鹽采用穩定、可靠的反滲透技術，技術先進可靠，保證了產水質量。 本系統根據進水水質及出水要求進行專門設計。 Pressure Parts （ 1） GB150 （ 2） ASME （ 3） Supervision regulation on safety technology for pressure vessel Materials （ 1） ASTM （ 2） ASME （ 3） Chinese Standard Piping/Flange （ 1） HG 2055393 (Pipes) （ 2） HG 20592~20635 (Flange, bolts, nuts, gaskets, etc) 制造及材料應符合下列標準和規程的最新版本的要求。S/cm （ max） Appearance 表觀： clear colorless liquid 無色 Oxidizable matter 可氧化物質 mg/L Residue 蒸發殘渣 2mg/L. 10t/h 脫鹽水系統