【導讀】CVM公司太平鎂廠管理制度規程匯編。8．車輛管理制度┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈Vehicle. 9．車輛日常維護使用管理制度┈┈┈┈┈┈┈┈┈┈┈┈┈Routine. 21．安全檢查和隱患消除┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈Securitycheck. 24．安全生產檢修管理制度┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈。31．設備檢修停送電安全規定┈┈┈┈┈┈┈┈┈┈┈┈┈┈。35．會議管理制度┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈Conference. 36．周一檢查制度┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈。38．鎂錠入庫制度┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈。42．事故管理制度┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈。7．人事管理員崗位職責┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈Personnel. 12．后勤人員崗位職責┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈Supportstaffjob. 14．調度崗位職責┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈。15．動力車間管理職責┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈┈。17．機修班崗位職責┈┈┈┈┈┈┈┈┈┈┈

　　

【正文】 he bus 設司機值班室，各類車輛司機 二十四小時 值班，確保為生產提供高效服務。Based driver duty room, all kinds of vehicles, drivers 24 hours on duty, ensure the provision of efficient services for the production Routine maintenance of vehicles 行車前 Before driving 檢查水、機油、燃料是否滿足運行，喇叭、燈光、雨刮器、反光鏡是否正常。 Check water, oil, fuel meets the run, speakers, lights, wipers, mirrors are normal 檢查各部位螺栓是否緊固，輪胎氣壓是否充足。 Check whether the bolts fastening the parts, tire pressure is adequate. 發動機啟動后，觀察有無異響，各儀表工作是否正常，要求不漏水、不漏電、不漏氣，制動性能及方向靈活有效。 Engine starts, observe any abnormal sound, the instrument is working properly, asked leak, do not leak, does not leak, brake performance and direction of the flexible and effective. 每周對各車輛加一次黃油，保證各部位有效運轉。 Once per week, plus butter on each vehicle to ensure the effective functioning of each part. 行駛中 Moving 檢查各儀表工作情況及轉向器是否正常。 Check the instruments work and the steering is normal. 觀察發動機底盤有無異響和異味。 Observe any abnormal sound, and smell the engine chassis. 檢查制動系統是否靈活有效。 Check brake system is flexible and effective 停車后 After stopping 檢查車輛燃油、潤滑油使用情況，清潔車內外表面。 Check vehicle fuel, lubricating oil use, clean car inside and outside surfaces. 檢查電路、喇叭、照明、雨刮器是否完好。 Check the circuit, speakers, lighting, wiper is intact 檢查鋼板、彈簧是否緊固，輪胎、氣壓是否充足。 Check the plate, spring is fastened, tires, air pressure is sufficient 查半軸羅絲及輪胎鋼圈羅栓是否緊固，水泵及風扇線松緊度。 Charlie Rose Axle and tire rims Lo bolt tightened, pumps and fans line tightness. 以上各條如有違反，罰款 10 元，情節嚴重加倍處理。 Any violation of the above article, a fine of 10 yuan, doubling and in serious cases Driver Code of Conduct 不聽指揮，不完成任務者，每次罰款 20 元。 Do not obey orders, who did not plete the task, a fine of 20 yuan each 未經廠領導和隊領導批準私自出車罰款 20 元。 Leadership and team leadership without factory approval of privately out of the bus a fine 20 不按時上下班，不請假，擅自離崗罰款 30 元。 Not to work on time, do not leave, undergo a fine of 30 yuan unauthorized 無故不參加車隊會議者罰款 20 元。 No reason not to participate in team meetings by a fine of 20 yuan 無證開車，自已不保養，不檢查造成損失罰款 50 元。 Driving without a license, not their own maintenance, do not check the damage caused by a fine of 50 yuan 不愛護車輛，自己不保養，不檢查造成損失罰款 50 元。 Do not take good care of vehicles, they do not care, do not check the damage caused by a fine of 50 yuan 私自教其他人開車罰款 50 元。 Secretly teach others to drive a fine of 50 yuan 酒后駕駛造成損失自負罰款 50100 元。 Drink driving, a fine of 50100 yuan loss of ego. 未經廠領導和隊領導批準私自開車回家過夜的罰款 50 元。 Without the approval of factory leaders and team leaders to drive home overnight without permission of fine 50 不按廠規 定亂停車者罰款 10 元。 Indiscriminate parking in accordance with the provisions do not plant a fine of 10 per person 廠區內吸煙者罰款 10 元。 Smokers fined 10 per plant in the region 出入廠區不戴安全帽者罰款 20 元。 Those who do not wear a helmet out of the factory 20 yuan fine 廠區內限速行駛，不聽話者罰款 10 元。 Plant in the region driving the speed limit, not the listener a fine of 10 yuan 叉車、鏟車嚴禁搭乘人違者罰款 10 元。 Forklifts, forklift ride is strictly prohibited and offenders fined 10 per person. 9. 車輛日常維護使用管理制度 Routine maintenance of vehicles using the management system Before driving 檢查水、機油、燃料是否滿足運行，喇叭、燈光、雨刮器、反光鏡是否正常，不按規定檢查罰款 10 元。 Check water, oil, fuel meets the run, speakers, lights, wipers, mirrors are normal, do not check the fine in accordance with the provisions of 10 yuan. 檢查各部位螺栓是否緊固，輪胎氣壓是否充足，不按規定檢查罰款 10 元。Check whether the bolts fastening the parts, tire pressure is adequate, do not check the fine of 10 yuan required. 發動機啟動后，觀察有無異響，各儀表工作是否正常，要求不漏水、不漏電、不漏氣，制動效能及方向機靈活有效，不按規 定檢查罰款 20 元。 Engine starts, observe any abnormal sound, the instrument is working properly, asked leak, do not leak, does not leak, brake and steering performance flexible and effective, does not check the fine of 20 yuan required. 每周對各車輛加一次黃油，保證各部位有效運轉，違 者罰款 10 元。 Once a week on all vehicles that butter, to ensure the effective functioning of each part, and offenders fined 10 yuan Moving 檢查各儀表工作情況及轉向器是否正常，發現問題不及時處理罰款 10 元。Check the instruments and the steering gear if the normal working conditions, found that the issue is not dealing with a fine of 10 yuan. 觀察發動機底盤有無異響和異味，發現問題不及時處理罰款 10 元。 Observe any abnormal sound and smell the engine chassis and found that the issue is not dealing with a fine of 10 yuan. 檢查制動系統是否靈活有效，不按規定保養罰款 10 元。 Check brake system is flexible and effective, do not follow the maintenance of a fine of 10 yuan After stopping 檢查車輛燃油、潤滑油使用情況，清潔車內外表面，不按規定辦理罰款 10元。 Check vehicle fuel, lubricating oil use, clean car inside and outside surface, do not follow the regulations a fine of 10 yuan 檢查電路、喇叭、照明、雨刮器是否完好，發現問題不及時處理罰款 10元。 Check the circuit, speakers, lighting, wiper is intact, the issue is not found to deal with a fine of 10 yuan 檢查鋼板、彈簧是否緊固，輪胎、氣壓是否充足，不按規定辦理罰款 10元。 Check the plate, spring is fastened, tires, air pressure is sufficient, do not follow the regulations of 10 yuan fine. 檢查半軸羅絲及輪胎鋼圈螺栓是否緊固，水泵及風扇線松緊度，發現問題不及時處理罰款 20 元。 Check Axle Rose and the tire rims are tightening bolts, water pump and fan tightness line and found the issue is not dealing with a fine of 20 yuan 10. 設備管理制度 為了保障我廠生產的安全運行，建立科學的設備管理體系，實現設備零缺陷，力爭運行無故障，確保設備的安全運行，無疑是我廠安全生產的頭等大事。設備是我廠生產的主要組成部分。要實現設備的安全運行，根據我廠各設備特點、使用與操作情況，特制定以下制度。 設備在安裝使用前必須報主管部門批準備案，取得使用登記證，并且有設備出廠合格證，檢驗報告。 司機及操作人員的上崗 設備人員上崗前，首先進行為期一周的廠部 安全教育，經考試合格后方可上崗，并進行一周車間與班組兩級安全教育。 廠內專業培訓，操作人員經安全教育合格后，需進行專業理論學習與實踐培訓，時間為一周，經考試合格后，由安全部門、機電動力科簽發安全作業證，方可上崗實習操作。 特種設備操作工經較長時間的學習鍛煉，由廠部推薦參加政府及行業培訓學習班學習，學習期間經考試合格，由相關部門簽發特種設備操作許可證，并接受每年一次的審查與檢測。 壓力容器的設備實施 24 小時監控，操作人員必須做好當班運行記錄，嚴格執行設備安全技術 操作規程，搞好設備日常維護，保持設備的完好清潔，做好設備交接班記錄。 設備的使用必須嚴格執行動力車間、安全生產技術科制定的規章制度操作，違者一般損壞按經濟責任處罰，造成重大傷害的，除名等處分，情節特別嚴重、損失巨大的要承擔法律責任。 設備的日常維護、巡查、點檢與潤滑必須嚴格執行《設備日常維護保養及安全運行制度》。 設備大中修計劃 設備檢修統一納入安全生產技術科