【導(dǎo)讀】Q?TY. PONO.C/NO.~~~~~~~~~~~~TTLQ?TYOFM/C:Q?TYPERM/C:TTLQ?TY:DATECODE:. INSP?N:. Pcs.Vibrationtest(1mastercarton)X,Y,Z,(30Min.peraxes)1M/C. Neutralas1cycle.as1cycle.

　　

【正文】 ust be verified by RSCNQC so as the test result. 5. 1 from 1000 units produced picked from different producing time will be used to do the tests unless specified Reference document/sample: 1. RadioShack Product requirement amp。 RadioShack reliability test standard 2. Product Spec Procedure amp。 method: 1. Master carton drop test (1 master carton) Weight less than Kg cm height 1 corner/3 edges/6 faces on concrete floor or steel board 2. Individual drop test w/gift box cm height 1 corner/3 edges/6 faces on concrete floor or steel board 3. Bare car drop test Drop the car with full speed 2 inches height to have the 4 wheel hits the concrete floor or steel board (drop 5times) Run the car and observe if any gear broken or abnormal gear noise 4. Tape and rubbing test Use 3M810 scotch tape or rubber eraser on chrome plate, silkscreen, sprayed painted, and silkscreen letters. Apply 3 times Confirm no peel up problem occurs. RadioShack Cat Page 15 of 22 5. Impact test Run the car full speed toward a test field concrete wall (w/line and angle marked), Hits the concrete wall 15 times straight Forward and with various angles then hits 1 time straight backward 6. Gear reliability/durability test Stop wheel test, run the car on the flat concrete floor w/full speed apply the stop 20 times Do the FWD/REV gear shift to assure the reliability of the gear by applying the FWDREV gear change during the full speed running. 7. Jump test (Curb test) Run the car full speed out of the curb (5cm height) 5 times. Confirm no any damage on the car 8. Dirt and water exclusion test Run the car into dirt and water (run a pack full charged battery). No damage should be found. 9. Climbing angle test Have the Tank run up the slop (specified angle 35 degrees) 10. Battery patibility test Use RadioShack battery or Duracell and Energizer to confirm the battery fitness and patibility. 11. Reverse polarity test Have RadioShack and/or Duracell /Energizer batteries installed reversed 1 minute. Confirm the effect of the battery reverse protection (mechanically) Battery can?t be installed reversed at all or no current drain. 12. Transmitter a) Current drain at 9V to confirm the forward/reverse/left/right/stand by current 30mA b) Minimum operating voltage at 6V to confirm the transmitter can work properly. c) Frequency shift at ?%, or 49 MHz band frequency within MHz ?% 13. Receiver a) Make sure the unit works over 3 min. per charge. 14. Motor a) Current drain at on RX to confirm the Forward/ Reverse 750mA. b) Current drain at on RX to confirm the Left/Right Turret turn, current 100mA 15. Charger stand: a) Current drain at 9V in charge mode 1200 or 800mA. Phenomena amp。 Criteria: Item checked Phenomena Criteria Master carton drop test Scuffing or damage on gift box Unit damage, detached, torn MA MA Gift box drop test Scuffing or damaged Coming apart at the seam of gift box Part detached, torn or damage MA MA MA Storage hot/cold test Air bubble on decal label, Label lifted up exceed 5 mm long Migration mark on car body Any wheel being pressed against packing material to cause Deformation after testing MA MA MA Bare car (w/full speed) drop test Gear broken Abnormal gear noise MA MA RadioShack Cat Page 16 of 22 Tape test (3M 810) or rubber eraser silkscreen, sprayed painted, and silkscreen letters e off MA Impact test: Straight forward w/various angles (both sides) Can?t work properly Gear broken Abnormal gear noise MA MA MA Gear reliability/durability test: a. Stop tread at full speed b. Forward/Reverse gear at full speed Can?t work properly Gear broken Abnormal gear noise MA MA MA Jump test (curb drop) Damage /Intermittent MA Climbing angle test Run up 35 digrees MA Battery patibility test Can?t fitting with the car MA Transmitter: Current drain at 9V: Forward/ reverse / left/ right/stand by current Minimum operating voltage at 6V Frequency shift at Out of spec (30mA) Can?t work properly Out of spec: MHz ? MHz ? MA MA MA Receiver: Current drain at 9V: ? Standby ? Forward/reverse Left/right spin current ? Minimum operating voltage at 6V Out of spec (30mA) Can?t work properly MA MA MA Motor: Current drain at : ? Forward/reverse ? Left/right spin current Out of spec (FWD 750mA, REV 650mA) Out of spec (900mA) MA MA 2. Checking Packaging Checking master carton Reference document/sample: 1. RSIP Change Shipping Mark on Export Carton 2. Shipping inspection request issued by RSCN Task to be pleted: 1. Verify master shipping carton shipping mark (refer to II1 above), 2. Visual check confirm no noticeable damage/torn/unfitness 3. Confirm the strength of seam strong enough by apply tear the box by hand to assure enough glue is used Phenomena amp。 Criteria: RadioShack Cat Page 17 of 22 Item checked Phenomena Criteria Master carton Scuffing or damage Incorrect shipping marked No bar code, bar code not readable by a bar code reader, And scanning the number can?t match Re. sample Master carton torn or damaged with product exposed Incorrect size of master carton or not uniform Poor seams of master carton MA M