word版可編輯-叉車充電站規劃設計技術要求batterychargingroomrequirement精心整理-資料下載頁
2025-05-29 22:49本頁面
【正文】 ：This calculation has to be done for all batteries in a charging room, that means the single volumes of airflow had to be added. 總的Q = Q1..Qn之和 = V Q total = sum Q1..Qn = V空氣air空氣air空氣air空氣air 空氣通風的構成 Construction of a ventilation專用電池充電房和充電站。Special for battery rooms and charging stations 6. 室溫和氣候 Room temperature and climate(“取暖”see also chapter heating)充電站應該具有+10 176。C到 +25176。C的室溫和干燥環境，以保證充電機和電池壽命。如果這些環境條件不能滿足，就要配備一些設備如：對充電機用空調，對電池用加熱電纜。設備的供貨商可以提供相關信息。A charging station should have a room temperature between +10 and +25176。C and a dry environment to solve the lifetime of chargers and batteries. Are these climate conditions not to realise so the used equipment had to be fit out for example air condition for the chargers or heating tables for the batteries. For this the supplier of the equipment can give information’s.7. 加水 Water topping帶液態電解液的電池，由于充電時會引起放氣過程而失去水分，必須再加水，根據DIN 43530或國標必須加蒸餾水，一般的水會破壞電池。由充電極控制的不需維護的自動加水系統對電池加水有益，在充電結束前的適當時間進行短時加水，電池必須有專門的添滿自關閉裝置 。自動加水系統的壓力應該是：最小 bar最大1 bar、 2到10米 ， 詢問電池供貨商有關加水系統的正確計劃。Batteries with liquid electrolyte lost water cause of the gassing during charge, this must be refilled. Therefor it must be used distilled water according DIN 43530 or national norms, normal water destroyed the battery. Automatically water topping systems without any maintain hold good cause controlled by the charger the refilling of water takes place at the correct time shortly before the charge will be finished. Batteries must have special selfclosing crams.The pressure of the automatically water topping system should have minimum 0,2 and maximum 1 bar, especially 2 to 10 meter. Ask a battery supplier for the correct planning of a water topping system.8. 搬運電池 Battery changing arrangements 起重設備，運輸車輛 Crane Equipments, changing lorries根據電池重量、數量和大小決定起重設備，運輸車輛，相關計劃詢問專門供貨商。Also for the planning of a crane equipment or changing lorries a special supplier had to be asked, this equipment depends of the quantity of batteries and the largeness and weight of the batteries.9. 維護和維修場所 Maintenance and repair places必須定期檢查和清潔電池，同樣根據DIN 0510每年必須檢查絕緣阻抗，如果阻抗太低，電池就要清洗。維護和維修場所必須用防酸材料與其他充電房隔離。 見 ，同樣大型充電站應該有專門的維修電池的場所，同時還有對電池充放電的充電機。Batteries must cleaned and checked periodically, also the isolation resistant must checked each year according DIN 0510, is the resistant too less the battery should be washed. This place must be separated of the rest charging room by acid resistance material, see also point floor conditions. At large charging stations also a special place should be installed to repair batteries equipped with a special charger to discharge and recharge the batteries. 10. 標識和規定 Labels and regulations單個充電場所應該有以下標識Single charging places should be labelled with following labels:電池危險警告Warning of danger of the battery嚴禁吸煙明火Prohibition of fire open light and smoking11. 急救措施 First aid對于由硫酸引起的事故，下面設備必須放在充電場所易見、易拿的地方。For accidents with acid the following equipment should be placed good visible and easy reachable near by the charging place.急救箱First aid case緊急沖洗Emergency shower洗眼站Eye washing station滅火器FireextinguisherAcid binding agent 12. 重要標準和規定Important norms and regulationsVDI 2197,2198,2199DIN VDE 0100DIN VDE 0510 part 3AGI J31 part 2 and part 3VDI 3616ZVEInorms13 / 1
研究報告相關推薦
鄂ICP備17016276號-1