【正文】 壓力容器的設備實施 24 小時監控，操作人員必須做好當班運行記錄，嚴格執行設備安全技術 操作規程，搞好設備日常維護，保持設備的完好清潔，做好設備交接班記錄。 Check the plate, spring is fastened, tires, air pressure is sufficient, do not follow the regulations of 10 yuan fine. 檢查半軸羅絲及輪胎鋼圈螺栓是否緊固，水泵及風扇線松緊度，發現問題不及時處理罰款 20 元。Check whether the bolts fastening the parts, tire pressure is adequate, do not check the fine of 10 yuan required. 發動機啟動后，觀察有無異響，各儀表工作是否正常，要求不漏水、不漏電、不漏氣，制動效能及方向機靈活有效，不按規 定檢查罰款 20 元。 Drink driving, a fine of 50100 yuan loss of ego. 未經廠領導和隊領導批準私自開車回家過夜的罰款 50 元。 Any violation of the above article, a fine of 10 yuan, doubling and in serious cases Driver Code of Conduct 不聽指揮，不完成任務者，每次罰款 20 元。 Once per week, plus butter on each vehicle to ensure the effective functioning of each part. 行駛中 Moving 檢查各儀表工作情況及轉向器是否正常。 Agricultural vehicles, forklifts, forklift trucks must ensure that the onsite production, the workshop car overall arrangement by the team leader in special circumstances, coordinated car from the dispatch room 駕駛員應經常保持車容整潔，車況良好，保證正常出車；車輛派出后駕駛員需認真負責，辦完公務后迅速返回，以便接受新的工作安排。 報廢的熱電偶絲，必須交回保管庫，并辦理相關手續。 范 圍 ：還原車間、煅燒車間、精煉車間 各車間爐子運行期間，車間負責人為熱電偶管理責任人，調溫 (操作 )工對當班熱電偶 使用情況全程監控，交接班記錄上必須注明熱電偶數量、完好率，并簽字認可。 40 次以上，安全員及班長等要重點監護。 ABOVEGROUND LPG STORAGE YARD RULES AND REGULATIONS amp。 ，煤氣壓力是否波動。 、廠相關制度，必須有供銷部提貨單和本廠領導簽字，否則，不予出庫。 。 銷毀制度：舊物品統一由核算員登記，將有價值可修復的部件交維修人員修復交庫建帳重新利用。對丟失、人為損壞的工器具考核責任人 1 分，并填丟失、損壞工具卡三份，其中一份交核算，一份交設備科，一份交車間保存，由核算員在當月工資中扣除丟失、損壞工具款。 Car insurances any temprorary used special tool approved by hours return after uses. To improved tool clean pleted (At least normal uses 2 point, car insurances 1 any special account connecting approved supplyby director. Facility Tool Car insurance procedures 車間公用工器具必須由車間指定專人保管，并做好工器具臺帳及管理工作。 In case of production losses, disaster relief, equipment maintenance and other special circumstances, the office director under specific conditions approved by the timely issuance of appropriate protective equipment 各車間發放勞保時，必須由職工親自在勞保領用表上簽字，并于當月 20日前交回綜合辦。 Our factory labor supplies the implementation of unified standards in accordance with pany instructions . 勞保用品管理原則 Labor Insurance supplies management principles 每月 15 日為廠向公司申報勞保計劃時間， 1015 日為本廠發放勞保時間。勞保用品發放由辦公室統一管理。 The workshop paid labor must be requisitioned by the staff person at the labor table to sign and return in the 20th month in running 未達到勞保使用周期而損耗的防護用品執行交舊領新制度。如發現丟失、人為損壞照價由車間賠償，并考核車間主任和保管人 2 分。 3. 備品備件管理制度 為了保證我廠正常生產，降低備品備件消耗，對備品備件的計劃、供給、領用、消耗等相關行為制定以下制度。無價值的半個月集中銷毀一次，由保管、核算、負責人和分管廠長參加。 、入庫必須辦理相關手續，成品帳必須日清月結。 。如有異常出現，應 立即報告相關領導和值班調度，以便及時處理問題，如因反饋不及時造成事故扣除 520 分。 (Rev. 0) Description This safety rules and guidelines describe the necessity action and precautions for all personnel entering the LPG storage yard. This document stresses on storage yard that is stored in aboveground vessels and barricaded by a fence or a wall. Objective The objective of this document is to ensure that all authorized personnel entering the storage yard is done in a safe manner and to increase risk mitigation for work done in and around the facility. Important Preparations I. Identify, inform and obtain permission from the Operator of the system. II. Only inducted and trained personnel who are familiar with the current LPG system are allowed entry to the facility. Inducted but untrained personnel shall be escorted by an inducted and trained or experienced supervisor at all times. III. All personnel shall only enter the facility if they are PROPERLY EQUIPPED with the following PPE as a minimum: o Safety helmet o Safety boots o Other PPE such as safety harness, safety goggles, respirator, etc shall be used as deemed appropriate. IV. Sources of ignition shall not be allowed into the facilities: o Electrical power tools. o Mobile telephones. o Cigarette lighters. o Naked flame of all sorts (inclusive of ignited cigarette buds) V. The above ignition sources shall not be allowed within the 30m proximity of the facility should there be any purging, leaking or any release of LPG gas. Instructions I. ENTRY INTO THE FACILITIES o The PersonInCharge will be responsible to ensure that there is no ignition of any kind is present before and during the progress of designated tasks/duties. Smoking is STRICTLY PROHIBITED in the facility。 ，影響坩堝使用壽命。 各車間爐子運行中熱電偶管理按第 1 條執行。否則照全價賠償，情節嚴重的，移交司法機關進行處理。 Car drivers should always be clean and tidy, good condition, to ensure the normal turnout。 Check the instruments work and the steering is normal. 觀察發動機底盤有無異響和異味。 Do not obey orders, who did not plete the task, a fine of 20 yuan each 未經廠領導和隊領導批準私自出車罰款 20 元。 Without the approval of factory leaders and team leaders to drive home overnight without permission of fine 50 不按廠規 定亂停車者罰款 10 元。 Engine starts, observe any abnormal sound, the instrument is working properly, asked leak, do not leak, does not leak, brake and steering performance flexible and effective, does not check the fine of 20 yuan required. 每周對各車輛加一次黃油，保證各部位有效運轉，違 者罰款 10 元。 Check Axle Rose and the tire rims are tightening bolts, water pump and fan tightness line and found the issue is not dealing with a fine of 20 yuan 10. 設備管理制度 為了保障我廠生產的安全運行，建立科學的設備管理體系，實現設備零缺陷，力爭運行無故障，確保設備的安全運行，無疑是我廠安全生產的頭等大事。 設備的使用必須嚴格執行動力車間、安全生產技術科制定的規章制度操作，違者一般損壞按經濟責任處罰，造成重大傷害的，除名等處分，情節特別嚴重、損失巨大的要承擔法律責任。 特種設備操作工經較長時間的學習鍛煉，由廠部推薦參加政府及行業培訓學習班學習，學習期間經考試合格，由相關部門簽發特種設備操作許可證，并接受每年一次的審查與檢測。 Check the circuit, speakers, lighting, wiper is intact, the issue is not found to deal with a fine of 10 yuan 檢查鋼板、彈簧是否緊固，輪胎、氣壓是否充足，不按規定辦理罰款 10元。 Check water, oil, fuel meets the run, speakers, lights, wipers, mirrors are n