齊齊哈爾大學化學工程與工藝專業畢業設計論文(年產5萬噸丙酮車間丙酮精餾工段初步設計)(已修改)
2025-06-07 17:55 本頁面
【正文】 I 摘 要 環己酮 又名尼龍酸，是己二酸生產過程產生的副產物，僅國內己二酸生產企業每年就副產混合二元酸 4060萬噸。由于其含雜質、水分多，顏色呈綠色或黃褐色，難以利用。國外一般將其送進污水處理裝置作焚燒或填埋處理；國內有采用重結晶法回收，但回收率低于 60％，廢水量較大，不僅對環境造成污染，而且也造成資源的浪費。 為了物盡其用， 本文 開展了應用基礎 研究 以 C4C6 混合二元酸為原料、對甲苯磺酸為催化劑，制備混合二元酸二甲酯，并利用減壓精餾得到純凈的二甲酯。實驗中考查了各種反應的影響因素，并利用制備的混合二甲酸二甲酯與 異辛醇進行酯交換制備混合二元酸二異辛酯。 關鍵詞 ： 環己酮 ； 環己烯 ；酯交換；混合二元酸二甲酯 Abstract Mixed dibasic acid (DBA), also known as nylon acid, adipic acid production process byproducts, only domestic producers of adipic acid byproduct mixture in each of dicarboxylic acid 4060 million tons. Because of its impurities, water content, the color green or brown, it is difficult to use. Foreign general to be sent to sewage treatment plant for incineration or landfilling。 domestic use II recrystallization recovery, but recovery was less than 60%, large amount of wastewater, not only pollute the environment, but also a waste of resources. In order to make the best use, this application of basic research carried out to C4C6 dicarboxylic acid as raw material mixture, ptoluenesulfonic acid as catalyst, prepared by mixing two yuan acid ester, and the use of vacuum distillation to get pure dimethyl ester. Experiment examined the response of various factors, and use a mixture of dimethyl ester prepared with different octanol prepared by mixing two yuan for transesterification ethylhexyl sebacate. According to the experimental data show that, by esterification of dicarboxylic acid mixture separation process route is feasible. Esterification of the appropriate reaction conditions: reaction time , alkyd molar ratio of 6:1, % mixed acid catalyst, in this condition, binary acid ester yield of 89%. Esters derived from crude esterification can be carried out under the pressure of 40mmHg vacu esterification can be effectively separated mixed dicarboxylic acid. Key words: mixed dibasic acid。 toluenesulfonate。 transesterification。 mixed two yuan Dimethyl III 目 錄 摘要 .............................................. 錯誤 !未定義書簽。 Abstract ........................................................... I 第 1 章 緒論 ........................................................ 5 課題的目的、意義 ............................................ 5 環己酮 的由來 ............................................. 5 環己酮 的利用 ............................................. 6 環己酮 的分離 ............................................. 6 環己酮 的用途 ............................................. 8 環己酮 制備的研究 ............................................. 9 固體酸 H 催化法 ........................................ 10 硫酸氫鈉催化法 ........................................ 11 固載磷鎢酸催化法 ...................................... 11 樹脂催化法 ............................ 錯誤 !未定義書簽。 一水硫酸氫鈉催化法 .................... 錯誤 !未定義書簽。 復合固體酸催化法 ...................... 錯誤 !未定義書簽。 雜多酸催化法 ............
研究報告相關推薦
鄂ICP備17016276號-1