【正文】 CHECK RELAYR1 檢查變速箱燈繼電器 REVERSE RELAYR3 TTRANS. CHECK LAMP 檢查變速箱燈 INPUTS/OUTPUTS SCHEMATIC TR45/60/70/100 輸入和輸出 原理圖 L3/E3 REVERSE ALARM/LAMP 倒檔警報器和燈 S18 HEADLAMP SW. 大燈開關 * K42 PRELUBE TIMER RELAY (TR100) K1 STARTER RELAY (TR45/60/70) K42預潤滑延時繼電器 * CEC2換檔選擇器上的燈 52 PRODUCT TRAINING (K20) LOCKUP OFF RELAY R6 (K35) BODY UP R4 (K39) DELTA PR5 Y13 RETARDER SOLENOID ZMANUAL LAMP MANUAL MODE KEY SWITCHS52 XDELTA P LAMP DELTA P SWS36 BODY PROXY S22 POWER/ECONOMYS53 INPUTS/OUTPUTS SCHEMATIC BODY UP LAMPH REF. RETARDER CONTROLS WRETARDER IND. LAMP E37 RETARDER LAMP(VEHICLE REAR) S7 PARK/EMERG. SW. S16 LOCK UP DROP OUT SW. S51 REVERSE HOIST INTERLOCK SW. 53 PRODUCT TRAINING GREY灰 1 16 17 32 (V) CONNECTOR . V插頭 54 PRODUCT TRAINING No. COLOUR WIRE DESCRIPTION TERMINATION 插頭 1 R 136V1 Main Power to ECU 主電源到 ECU VIWA 3 O 132V3 Converter Drive Warning Light 變扭器工作燈 VIWE 4 W 113V4 Reverse Alarm 倒檔警報 VIWF 6 N 123V6 Neutral Start 空檔啟動 VIWG 14 N 177V14 Reverse Hoist Interlock 舉升倒檔互鎖 VIW2 16 R 136V16 Battery Power 電瓶電源 VIWB 17 B 143V17 ECU Earth ECU 接地 VIWC 22 N 112V22 Overspeed Warning Light 超速警報燈 VIWH 26 K 146V26 Engine Run Signal 發動機運行信號 VIW1 27 W 154V27 Lock Up Off Signal 閉鎖解脫信號 VIW3 28 O 178V28 Retarder Apply 緩行器實施 VIW4 29 O 137V29 Park Brake Interlock 駐車制動抑制檔位 VIW5 30 G 117V30 Delta P Switch ΔP 開關 VIW6 31 Y 161V31 Isolated Return 單獨回路 VIW7 32 B 143V32 ECU Earth ECU 接地 VIWD (V) CONNECTOR . TYPICAL ARRANGEMENT 55 PRODUCT TRAINING Manual Light 手動方式指示燈 INTERFACE BOX – MODES接線盒 方式選擇 S52 Manual/Automatic 手動 /自動方式 S53 Power/Economy 動力 /經濟 Interface Box Decal 56 PRODUCT TRAINING REVERSE HOIST INTERLOCK 倒檔舉升互鎖 REVERSE HOIST INTERLOCK PRESSURE SWITCH倒檔舉升互鎖壓力開關 ? Reverts to Neutral (N) If Body Is Raised When Reversing 舉升時掛倒檔則返回到空檔 ? 177 ECUV14 RNR S51 S51 57 PRODUCT TRAINING BODY UP LOCK IN RANGE 舉升檔位鎖定 MAGNETIC BODY SWITCH 磁性舉升開關 ? PREVENTS UPSHIFTS WHEN TRAVELING IN FORWARD GEAR AND THE BODY IS RAISED. DOWNSHIFTS AND HOLDS IN 1st. 防止升檔 車輛掛前進檔且車箱處在舉升狀態 ,變速箱自動降檔并保持在一檔 ? TO BODY UP RELAY (K35) IN INTERFACE BOX 163 ECUS27到接線盒中的車箱舉升繼電器 163 ECUS27 S22 58 PRODUCT TRAINING L/U OFF PRESSURE SWITCH 閉鎖解脫壓力開關 L/U Off Pressure Switch S16 閉鎖解脫壓力開關 Stop Lamp Switch 剎車燈開關 L/U OFF PRESSURE SWITCH 閉鎖解脫壓力開關 ? DISABLES LOCK UP CLUTCH. ACTIVATED BY 20 BAR SWITCH ON BRAKE PEDAL 20巴 解脫閉鎖離合器 ? TO LOCK UP OFF RELAY (K20) IN INTERFACE BOX 154 ECUV27到接線盒中的閉鎖解脫繼電器 154ECU –V 27 59 PRODUCT TRAINING DELTA (?) P FILTER SWITCH ΔP濾清器開關 DELTA (?) P FILTER SWITCH 濾清器開關 ? PREVENTS UPSHIFTS WHEN SWITCH REGISTERS A ? P OF BAR(35PSI). HOLDS IN 1st. VIA K39 RELAY INTERFACE ,由 K39繼電器防止升檔并保持在一檔 ? TO ? P RELAY 117 ECUV30 ? 到 ΔP 繼電器 117ECUV30 S36 S36 60 PRODUCT TRAINING INDICATOR WARNING LIGHTS 警報燈指示 1 4 2 3 1 Transmission Check Light 檢查變速箱燈 2 ? P Filter Light ΔP 濾清器阻塞燈 3 Transmission Overspeed 變速箱超速燈 4 Converter Drive Light 變扭器工作燈 1 ILLUMINATES WHEN ECU SENSES FAULT VIA CHECK TRANSMISSION RELAY K60 115 ECUS31 通過檢查變速箱燈繼電器將該燈點亮當電腦檢測出故障時點亮 2 ILLUMINATES ON TRANSMISSION FILTER RESTRICTION VIA ?P SW. S36 117 ECUV30 當變速箱濾清器阻塞時由 Δ開關 S36點亮 3 ILLUMINATES WHEN TRANSMISSION EXCEEDS 2350 RPM 112 ECUV22 當變速箱速度超過 2350轉 /分點亮 4 ILLUMINATES WHEN IN CONVERTER MODE CONVERTER MODE RELAY K20 132 ECUV3 變扭器模式 變扭器模式繼電器 K20132ECUV3 61 PRODUCT TRAINING PULSE PULSE TACHO CALIBRATION INPUT轉速校核 TR35 Pulses TR40 Pulses TR45 Pulses TR60 Pulses TR70 Pulses TR100 Pulses SPEEDO CALIBRATION INPUT 速度校核輸入 All with standard tyres所有具有標準輪胎 TR35 202021 TR40 188600 TR45 188600 TR60 208580 TR70 208580 TR100 249120 SPEEDO/TACHO CALIBRATION速度校核 62 PRODUCT TRAINING TRANSMISSION HARNESS 變速箱線束 63 PRODUCT TRAINING Blue藍 1 16 17 32 (T) CONNECTOR . 64 PRODUCT TRAINING WIRE線號 DESCRIPTION TERMINATION 1 O 102T1 Solenoid Power, Solenoids F, G amp。 B電磁閥電源和電磁閥 A B MNVBA, MNVBC 19 Y 116T19 Solenoid Power, Solenoids E, D amp。 I SOLENOIDS TR100 H和 I 電磁閥 H (1st Range), I (Lock in Range) Solenoid Housing H(一檔 ),I(檔位鎖定 )電磁閥殼體 H I H, I Housing Connector H I殼體接頭 A 107T3 Solenoid Power – H 電磁閥電源 B 110T22 Solenoid Low –電磁閥接地 C 111T8 Solenoid Low 電磁閥接地 D 102T1 Solenoid Power F/G/I 電磁閥電源 E Spare 備用 70 PRODUCT TRAINING M5610/6610 GR ACTIVE SOLENOID CLUTCHES ENGAGED 6 E, G High Range/High Splitter 高速檔 /副變速器高速檔 5 E, F High Range/Low Splitter 4 D, G Intermediate Range/High Splitter 3 D, F Intermediate Range/Low Splitter 2 C, G Low Range/High Splitter 1 C, F Low Range/Low Splitter N *A, F Low Splitter (F) R1 *A, B, F Reverse/Low Splitter R2 *A, B, G Reverse/High Splitter GEAR SOLENOID ACTIVATION TR45/60/70 *ASolenoid Activates No Clutch Lock In Range 71 PRODUCT TRAINING CLUTCH ARRANGEMENT TR45/60/70 M5610/6610 72 PRODUCT TRAINING M8610 SERIES 系列 GR檔位 ACTIVE SOLENOID 通電的 電磁閥 CLUTCHES ENGAGED(接合的離合器 ) 6 E, G 5th/6th Range/High Splitter 5 E, F 5th/6th Range/Low Splitter 4 D, G 3rd/4th Range/High Splitter 3 D, F 3rd/4th Range/Low Splitter 2 C, F 2nd Range/Low Splitter 1 H, F 1st Range/Low Splitter N A, F, I Splitter Low (F) (A amp