【正文】 Project general 項目概述 This bid document is made out according to Material Requisition For Desalted Water Package (X7600) provided by **** (LYG) ENGINEERING CO., LTD. And this proposal is special for **** (Huizhou) LTD 10t/h desalted water system. 本投標文件是依據北京 ****工程技術有限公司提供的 X7600《 除鹽水系統請購單 》 編制 ， 適合于 ****有限 公司 10t/h 脫鹽水系統 。根據水質特點和招標文件要求，遵循工藝技術先進，運行安全可靠，節能、節水、環保，保證系統能長期穩定運行10t/h 脫鹽水系統 3 的原則，確定本套系統主工藝為：砂過濾器 +活性炭過濾器 +兩級反滲透。 全套系統采用 PLC 自動控制，含 DP 接口，可實現全自動控制和遠程監測DCS 控制。S/cm Quantities 設備套數 ： 1 set 套 DI water quality 脫鹽水水質 According to the GB/T66822020 Water for analytical laboratory useSpecification and test methods, we need the desalted water of class III as our water quality for our desalted water. PH , conductivity at 25℃ 5181。S/cm （ max） Appearance 表觀： clear colorless liquid 無色 Oxidizable matter 可氧化物質 mg/L Residue 蒸發殘渣 2mg/L. 10t/h 脫鹽水系統 7 四、 Design amp。 本系統根據進水水質及出水要求進行專門設計。 proposal design idea 方案設計思路 The treatment process, sand filter amp。反滲透可降低水的含鹽量和電導率，使出水水質符合要求。 為了保證反滲透系統正常運行，需定期對預處理系統出水水質進行檢測，檢測水樣從碳濾器產水總管采集，采用人工檢測，檢測頻率初定為一天兩次，主要檢測指標為 SDI值。根據招標書要求，原水箱容積為 15m3，材質為 PE， 為了便于控制，原水箱配液位開關。 (3) Dosing system 加藥系統 The system is equipmented with coagulant dosing and bactericide dosing system here. 10t/h 脫鹽水系統 16 Through coagulant dosing system, coagulants will add into the raw water to congregate the suspended solid, anic pound, colloid, etc to prove filtration efficiency. The impurity such as suspended solid, colloid generally be of homo electric charge, which made them exclude each other and hard to congregate. coagulant is kind of long chain macromolecule. It can neutralize the doubleelectric layer of colloid and counteract heterogeneous group as well as adsorb the suspended solid, anic pound, colloid and congregate them to big objects and then removed by sand filter. Bactericide dosing system is used to prevent the growth of animalcule. 加藥系統分為 混 凝劑加藥系統與殺菌劑加藥系統。 殺菌劑加藥系統的作用是防止微生物生長。 ——采用較低的運行流速，以適應地表水的特點。反洗的過濾器完成反洗過程后，自動進入運行狀態。 總體過濾面積： 178。 活性炭過濾器同砂過濾器，均采用多路閥控制，活性炭過濾器反洗采用砂過濾器產水反洗，采用時間控制，即當任何一臺活性炭濾器運行時間達到設定值時，則停止運行。 filtrate flow velocity： filtrate flux of unit： quantity： 1sets multiway valve： 1set installation form： Top entry 活性炭濾器系統參數 過濾系統型號： Ф900H1800mm 材質： FRP 單元過濾面積： 178。 中間水箱設計參數： 水箱容積： 15m3 水箱尺寸： Φ27202800mm 水箱材質： PE 結構形式：圓形平底水箱 液位 開關 ：配液位 開關，帶開關量輸出 RO DI system 除鹽系統 —— 反滲透系統 process description 工藝過程描述 The outlet water of activated carbon filter will be collected in the Intermediate storage tank and supply to the RO system by 1st pass RO supply pump. Scale inhibitor will be adding into the water before entering the 1st pass RO security 10t/h 脫鹽水系統 24 filter. The filtrated water will be pressurized by high pressure pump and feeding to 1st RO. The outlet water of 1st pass RO will be of low of pH and with a quantity of carbon dioxide. NaOH will be dosing to 1st pass RO outlet water to wipe off the carbon dioxide and acmodate the pH value. Then the acmodated water feed into 2nd pass RO by 2nd pass high pressure pump. After the 2nd pass RO treatment, the DI water will collected in the DI water tank and then boost up to the user. The online flow meter and conductivity meter is available on the outlet pipe of to ensure the satisfaction of water quality and quantity which is visible on the display of PLC. 活性炭過濾器的產水收集在中間水箱，由一級 RO 供水泵提供給反滲透系統，活性炭過濾器產水經一級 RO 供水泵加壓，加入阻垢劑，進入一級 RO 保安過濾器，經過濾的水由一級高壓泵升壓，使其滿足一級反滲透裝置的操作壓力，然后送入一級反滲透膜裝置，一級反滲透的產水由于 PH 值較低，水中可能帶有部分二氧化碳氣體，因此，一級 RO 產水需加入 NaOH 調節其 PH 值，去除水中的二氧化碳，一級 RO 產水直接由二級 RO 高壓泵加壓后，供給二級 RO 系統處理，經過兩級反滲透處理后的脫鹽水，收集在脫鹽水箱中，由脫鹽水供水泵供用水點使用。 一級 RO 供水泵參數如下： 流量： 揚程： 30m 功率： 3KW 10t/h 脫鹽水系統 26 材質： SS304 數量： 2 臺 （ 1 用 1 備） （ 2） Scale inhibitor dosing set 阻垢劑加藥裝置 To avoid the chemical scaling of RO concentrated water side especially the last one membrane element bring by high recovery rate, scale inhibitor will be added into the water before feeding to RO set to protect the membrane from performance infection. BWA high efficiency scale inhibitor is used in this system. As a king of dispersant masking agent， it has the points as follows： ★ High scaling efficiency: It can keep the system from scaling within LSI value (maximum allowable value) without acid. ★ The main ponent small phosphorus anic pounds are chemical steady in water, and won’t change into nutrimental phosphate. The drain won’t bring pollution to the environment. ★ With the excellent dispersion property, iron, aluminum and heavy metal pollution will be controlled and iron colloid and granule will be dispersed. 為了在較高回收率情況下防止反滲透濃水端特別是反 滲透壓力容器中最后一根膜元件的濃水側出現碳酸鹽、硫酸鹽和 Ca2+、 Mg2+離子的化學結垢，從而影響膜元件的性能，在反滲透進水前需要加入阻垢劑。 Scaling inhibitor dosing system design parameter： 10t/h 脫鹽水系統 27 Dosing quantities： 5ppm Chemical concentration： 10% valid concentration Chemical name： BWA scale inhibitor Metering pump parameter： flux： pressure： power： 70w quantities： 1set Dosing tank parameter： capacity： 60L size： Ф450550mm material： PE quantities： 1set 阻垢劑加藥設計參數： 加藥量： 5ppm 藥劑濃度：有效濃度 10% 藥劑名稱： BWA 阻垢劑 計量泵參數： 流量： 壓力： 功率： 70w 數量： 1 臺 加藥箱參數： 容積： 60L 尺寸： Ф450550mm 材質： PE 數量： 1 臺 10t/h 脫鹽水系統 28 （ 3） 1st pass RO security filter 一級 RO 保安過濾器 Granule (equivalent diameter 5?m) can breakdown the membrane and resulting in saltleakage and injure the high pressure impeller. A security filter is just fitted before RO set to prevent the granule entering the RO system and protect RO from damage. SS304 vessel and meltblown PP filter core is used