應用化學專業文獻翻譯中英文對照-文庫吧
2024-11-16 04:08 本頁面
【正文】 certain operating temperature,increasing the operating pressure can increase the productive capacity of the tower,so that stable operation,but the content of volatile group in the tower reactor distillation,often provides for the adjustment range of the operating the fallout of the operating pressure by extmrnal factors,were destroyed,the normal operation of the tower will be pletely destroyed. Feeding temperature Condensate feed,the feed temperature is lower than the temperature of the feeding board,and added if all the material into the stripper segment,stripping segment load increases,the reboiler consumption increase in the amount of steam,and the top of the tower is difficult volatile group were lower. Saturated steam feed,the feed material temperature is higher than the temperature of feed board,all the material of the feed into the rectifying section and stripping section of the load reduction,and increased load of the rectifying section,make the top product quality reduce. Feeding quantity and position changes Changes in the feedstock of a direct impact on the change of the amount of steam,the latter increase will produce entrained,even feedstock is too low,the operation is not good to maintain the balance of the tower,the steam velocity decreases,the plate is prone to leakage,the rectification efficiency is lowload operation,may be appropriate to increase the reflux ratio,the tower operating in a load lower limit above normal and stable operation in order to maintain the ponent of the changes directly affect the product restructuring concentration increase in the rectifying section load separation is not good,the results of restructuring were brought to the top of tower,causing the top of the tower of inferior from the reboiler,the top of the tower losses the concentration of the volatile group in the feeding group were 本科畢業設計 —— 文 獻翻譯 3 increased,and the stripping section of the load increases,may be poor due to the separation caused by the tower reactor products of inferior quality,which entrained volatile ponents restructuring concentration increased,the feeding mouth move down and vice versa,then move same time,operating temperature,back flow and operating pressure must be adjusted accordingly in order to ensure the stability of the distillation operation. Distillation,increasing the reflux ratio,can improve the quality of the product,but the reflux ratio is too large,the inner loop of the tower increased,increasing energy of the reflux ratio,the tower gasliquid contact is not good,the balance to damaged and therefore the mass transfer efficiency same time,the operating pressure drop,difficult volatile ponents easily brought to the top of the tower,resulting in a substandard product. 2 Anomalies in the distillation column during operation Plate capacity Rectifying section tray downer overflow liquid transportation,however,that t
研究報告相關推薦
鄂ICP備17016276號-1