【正文】 gnal 、protection、control line between the truck and the switchgear is connection with the pin of control line. The truck is fixed on the test position as soon as it is pushed into the switchgear, and be connection to the earth system of the switchgear. The position of truck will be seen by the lamp that is installed on the looking window or the panel of lowvoltage.Beside the VCB, the Truck can be equipped the vacuum contactor 、isolated device and the measuring equipment.母線室 Bus bar partment母線從一個開關柜引至另一個開關柜，通過分支母線和套管固定。手車能在開關柜門關閉的情況下操作，通過門上的觀察窗可以看到手車的位置、手車上的ON（斷路器合閘）/OFF（斷路器分閘）按鈕、合分閘狀態指示器和儲能/釋放狀況指示器。三個高壓室的頂部都裝有壓力釋放板。*配VD4斷路器可用。This product should not be used under conditions of fire, explosion，earthquake and chemical corrosion environments.Special service conditions對特殊工作條件，必須向制造廠咨詢。開關柜的可移開部分可配置真空斷路器和真空接觸器等元器件。 Observe the relevant information in the instruction manual for all actions involving switchgear and switchboards.危險Danger要特別注意說明書中標有這個危險標志的注意事項。Comply in full with the legally recognized standards（DIN VDE/IEC），the connection conditions of the local electrical utility and the applicable safety at work regulations.有關開關設備的一切操作，都要遵守說明書中的相應規定。Contents1．12345Summary GeneralStandards and specificationsService conditions Normal Service conditions Special Service conditionsMatters need attentionTechnical dataSwitchgear electrical dataReceived internal arc natureDimension and weightsStructure summary Basic structure and variantsEnclosure and partitionsCompartments in the switchgear panelsInterlocks/protection against mishandlingDespatch and storageCondition on deliverPackagingTransportDelivery and intermediate storageAssemblage of the switchgear at siteGeneral site requirementsBasic scheme of switching room’s play layout.FoundationFoundation as the floorboard of switching room.Foundation frame on a concrete floorInstalment and joint of switchgearInstalment and joint of bus barContact of power cable and control cable.Join of the earth bus barThe epilogue of erecting workPage666677888910121213131620202021222424242525262729303132Contents67Switchgear runningStartupPreparation workStartupOperation of the switchgearVCB truckVCBEarth switchCable doorElectrical/mechanical indicate/monitorMaintenanceGeneral Checking and maintenance MaintenanceCheckingChange elementSpares*The data and illustrations are without engagement .Subject to change without notice.Page3737373940404243444445454649494949We reserve all rights to this publication. Misuse, particularly including duplication and making available of this manual extractsto third parties is prohibited. The information supplied isn’t liability，subject to approval.1 總則 Summary 概述 GeneralKYN2812鎧裝式金屬封閉開關設備（以下簡稱KYN2812開關柜）適用于三相交流50Hz、~12kV單母線及單母線分段電力系統，具有“五防”功能。CMinimum (according to “minus 15 indoor class”)室內環境濕度：Ambient humidity in room： 日平均相對濕度 95%及以下Daily average relative humidity less than 95%月平均相對濕度 90%及以下Monthly average relative humidity less than 90%安裝場所的海拔高度 1000m及以下Height above sea level at site less than 1000m地震烈度: 不超過8度Earthquake intensity: less than 8 degree沒有火災、爆炸危險，沒有嚴重污穢及化學腐蝕的場所。KYN2812 has been considered with the problem of inside fault arc in switchgear on design. It is tested strictly according to GB3906 and IEC298, thus ensure effectively the safety of equipments and operation personnel. Outline dimensions and weight 外形尺寸 Outline dimensions高度a （mm） 2200寬度b （mm）分支母線額定電流為1250A及以下， 800/650*分支母線額定電流為1600A及以下，短路開斷電流為40kA 800分支母線額定電流為1600A及以上 1000深度c （mm） 1350/1500Height a 2200（mm） Width b Rated branching bus bar current up to 1250A，Rated shortcircuit breaking current(rms.) up to 800/650*（mm）Rated branching bus bar current up to 1600A，Rated shortcircuit breaking current(rms.) up to 40KA 800 (mm)Rated branching bus bar current over 1600A， 1000(mm)Depth c 1350/1500 （mm） 重量800~1200kg，詳細資料見表1。The basic structure of switchgear panel prises the panel itself a removing part. The panel and main ponents can see in figure 3/ panel or outgoingline panel are diagram of basic switchgear panel，there are other derivative diagram，for example ,contact panel or metering panel .in addition，There are so many diagram of the switchgear panel with stationary type load switch、（SF6）VCB truck、VC truck、Disconnect truck. The panel has two maintenance modes. That is singleface maintenance and doubleface maintenance. The detail of structure and main ponents, can reference order document. Enclosure and clapboard開關柜的外殼和隔板由優質鋼板制成，具有很強的抗氧化、耐腐蝕功能，且剛度和機械強度比普通低碳鋼板高。當手車從運行位置向試驗/隔離位置移動時，活門會自動蓋住靜觸頭，反向運行則打開。除真空斷路器外，手車可配真空接觸器、隔離裝置和計量設備等。當電纜室門打開后，有足夠的空間供施工人員進入柜內安裝電纜（最多可并接6根）。聯鎖裝置地功能如下：A series of interlocks are provided to prevent mishandling, thus protecting both personnel and switchgear itself. The function of interlocks is following: 216。 手車在運行位置時，控制線插頭被鎖定，不能拔出。母線、緊固件和附件是單獨包裝的。 用吊車裝載Load